The Writer's Lifestyle

A fountain pen that is not flowing is almost always a pen with dry ink in the feed, an unpierced cartridge, or an air lock. It is rarely broken. Work through five fixes in order of effort — a re-prime on paper, a re-seated cartridge, a warm-water soak, a full flush, and a new nib — and the pen starts writing again at one of the first three steps. This guide covers pens that will not start at all: the pen left in a drawer for a month, the new pen that writes nothing out of the box, the pen that went dry mid-page and stayed that way. It sits alongside our guide to pens that skip intermittently, which is a different problem. Every fix below works on any pen in the Wordsworth & Black fountain pen range. Key Takeaways A pen that will not start has one of four causes: dried ink in the feed, an unpierced or unseated cartridge, an air lock, or leftover manufacturing residue on a new pen. Start with the cheapest fix. A 60-second re-prime on paper revives most pens that sat for days. A nib swap is the last resort, not the first. Use lukewarm water, never hot. Hot water can warp plastic feeds and loosen the nib unit. A full cartridge that will not flow usually has not been pushed far enough onto the pin inside the section. One firm push settles it. Pens left unused for more than two weeks need a flush before refilling. Fresh ink over dried ink clogs again within a page. Rotate pens weekly and store them nib-up. This one habit prevents most dry-out cases. Why a Fountain Pen Stops Flowing Ink reaches the page by capillary action. It travels from the reservoir through the feed, a slotted comb under the nib, to the narrow slit between the nib's two halves. Break that chain anywhere and the pen goes silent. The break is nearly always at the feed or the reservoir connection. Dried ink in the feed Water evaporates from ink left in the feed channels. What stays behind is dye and pigment that blocks the slot. The longer the pen sits uncapped or loosely capped, the harder the blockage. Bottled and cartridge inks dry at similar rates, so the fix is the same either way. A cartridge that never connected Standard cartridges have a sealed tip. The pin inside the section has to pierce it. Push too lightly and the ink never moves, even though the cartridge looks full. This is the most common reason a brand-new pen writes nothing. An air lock A bubble of air trapped between the ink and the feed stops capillary flow. It happens after an incomplete converter fill or a pen stored nib-up with very little ink left. Gravity and a gentle flick usually break it. Residue on a new pen New nibs and feeds can carry a thin film from manufacturing, so the first fill beads up instead of wetting the feed. A short soak in lukewarm water with a drop of dish soap clears it. The Two-Minute Check Before Anything Else Before you soak or flush anything, rule out the simple causes. Each takes under a minute and costs nothing. Look at the ink level. Cartridge empty? Converter run dry? Swap or refill before troubleshooting. Check the cartridge seating. Unscrew the barrel, hold the section, and push the cartridge onto the pin until you feel it click. A fresh cartridge should show a bead of ink at the neck. Look at the nib. The two halves, called tines, should sit flush. If they are visibly pinched together or sprung apart, stop. Do not write with it. Write on dry, smooth paper. Greasy or very rough paper can mimic a dry pen. Our paper guide explains which surfaces help. The Recovery Ladder: Five Fixes in Order Each step is more involved than the last. Stop at the first one that works. Fountain pen recovery ladder: five fixes in order of effort Recovery ladder: stop at the first step that works1Re-prime~1 min2Re-seat~2 min3Warm soak~10 min4Full flush30 min+5New nib~5 minEffort rises left to right. Times are approximate. Source: Wordsworth & Black Most dried-out pens recover by step three. Steps four and five are rarely needed. Step 1: Re-prime on paper (about 1 minute) Hold the pen nib-down for ten seconds so ink settles toward the feed. Then draw slow loops on a scrap of smooth paper. If the pen was only idle for a few days, ink returns after a few lines. Pressing the nib flat against the paper while it is uncapped helps wick ink forward. Step 2: Re-seat the cartridge or refill the converter (about 2 minutes) Unscrew the barrel and press the cartridge firmly onto the pin. With a converter, twist the knob until a drop forms at the nib and wipe it away. If the converter was only part filled, dip the nib in ink and fill it again completely, then check the converter is seated and the piston moves freely. Our guide to cartridge, converter and piston fill systems shows what a correct fit looks like. Step 3: Warm-water soak (about 10 minutes) Unscrew the barrel and remove the cartridge or converter. Dip the nib and section in a glass of lukewarm water, enough to cover the feed but not the grip threads. Leave it for ten minutes, then blot dry. Dried ink dissolves and clouds the water. This fixes the large majority of pens left unused for weeks. Step 4: Full flush with pen cleaner (30 minutes to overnight) For a stubborn blockage, soak the section in a pen cleaner solution. The Wordsworth & Black Fountain Pen Cleaner (30 mL, $19.90) is made for this. Rinse in plain water until it runs clear. Our full cleaning guide covers the routine step by step. Step 5: Replace the nib unit (about 5 minutes) If a flush does not restore flow, the feed or tines may be damaged. A replacement nib ($9.99) is a cheap fix. Browse the spare nibs collection and check the nib fits your pen before ordering. Our nib guide explains sizes if you want to try a different width. What to Do With a Brand-New Pen That Will Not Write A new pen that refuses to write is almost never defective. The two usual causes are an unpierced cartridge and factory residue on the feed. Check them in this order: Unscrew the barrel and confirm the cartridge is pushed fully onto the pin. Squeeze the cartridge gently, nib down, until ink appears at the tip. If the feed still beads, soak the nib in lukewarm water with one drop of dish soap, rinse, and refill. Write on smooth paper with a light touch and no pressure. Let the nib do the work. A pen from the Crest range or the Erudite range needs the same treatment. The usual culprit is a cartridge that has not yet been pushed home. Comparing the Causes and Their Fixes Symptom Likely cause First fix New pen, nothing at all Cartridge not pierced Push cartridge firmly onto the pin Wets, then dies after a line Air lock or factory residue Flick gently nib-down, then soak in lukewarm water Idle for days, scratchy start Light dry-out Re-prime on paper Idle for weeks, dry feed Dried ink in feed Warm-water soak Flushed twice, still dry Damaged feed or tines Replace the nib unit How to Keep a Pen From Drying Out Again Dry-out is a storage problem, not a pen problem. Four habits prevent nearly all of it. Cap firmly every time. Capped pens keep the nib moist for weeks. An uncapped nib starts drying within minutes. Rotate weekly. Write a few lines with each pen in your rotation once a week. A few lines is enough. Store horizontally or nib-up. Nib-down storage pushes ink into the cap. Nib-up with a nearly empty reservoir can trap air, so refill before long storage. Flush before long breaks. If a pen will sit for a month or more, empty and rinse it. Our ink storage guide covers the bottle side. If you rotate several pens, a bottled ink in nine colors lets you keep each pen dedicated to a color. A dedicated pen is easier to track, and a pen you track is a pen you write with. When a Pen Is Genuinely Faulty A pen that fails every step above, with a fresh cartridge, a clean feed and undamaged tines, has a hardware fault. Look for a cracked feed, a nib pushed out of alignment, or a section thread that does not seat. Stop troubleshooting at this point. Further soaking will not repair mechanical damage. Frequently Asked Questions Why is my fountain pen not writing even though it has ink? The ink is not reaching the nib. Usually the feed is blocked with dried ink, the cartridge has not been pierced by the pin, or an air bubble sits between the ink and the feed. Re-seat the cartridge first, then try a warm-water soak. How long can a fountain pen sit unused before it dries out? A capped pen with ink usually survives one to two weeks. After two to four weeks the feed often starts to dry, and after a month or more a flush is usually needed. Rotating pens weekly prevents the problem. Can I use hot water to unclog a fountain pen? No. Hot water can warp plastic feeds and loosen the nib unit. Lukewarm water is enough to dissolve dried ink. If a blockage resists a soak, use a pen cleaner solution rather than hotter water. Why does my new fountain pen not write? The most common cause is a cartridge that has not been pushed fully onto the pin, so it has not been pierced. The second is manufacturing residue on the feed. Press the cartridge home, then soak the nib in lukewarm water with a drop of dish soap if needed. How do I get ink flowing again after refilling? Hold the pen nib-down for ten seconds, then draw slow loops on smooth paper. If the converter was only part filled, refill it completely. An air lock usually clears after a gentle downward flick and a few lines of writing. Should I soak the whole pen in water? No. Soak only the nib and section. Keep the barrel, cap and any converter mechanism out of the water. Remove the cartridge or converter first. Dry the section with a soft cloth before refilling. Is a pen that will not flow broken? Rarely. Most non-flowing pens recover with a re-prime, a cartridge push, a soak or a flush. A pen is faulty only if it fails after a clean flush with fresh ink and undamaged tines. At that point, replace the nib unit. How is this different from a pen that skips? A skipping pen writes, then drops out mid-line. A pen that is not flowing never starts, or stops completely. Skipping usually points to feed wetness or paper. See our skipping guide for that problem. Final Verdict Do not buy a new pen yet. Most dried-out pens recover with a push, a soak or a flush. Keep a bottle of the pen cleaner ($19.90) on hand for stubborn blockages, and a spare nib ($9.99) for the rare pen that needs one. If you are ready for a fresh start, the Fountain Pen Starter Kit ($54.99) bundles everything in one box. → Browse all Wordsworth & Black fountain pens